Product ID:ROYCO 777,LOW TEMPERATURE HYDRAULIC FLUID,MIL-H-87257
MSDS Date:01/22/1996
FSC:9150
NIIN:01-391-2087
MSDS Number: CJCXW

Emergency Phone: 973-887-7411

Cage: 6V632

Telephone: 973-887-7411/7410

Cage: 07950

SYNTHETIC HYDROCARBONS

SYNTHETIC ESTERS

MINOR ADDITIVES

LD50 LC50 Mixture:NO DATA PROVIDED BY RESPONSIBLE PARTY.
Routes of Entry: Inhalation:NO Skin:NO Ingestion:NO
Health Hazards Acute and Chronic:ACUTE: EYES: NO MORE THAN MINIMALLY
IRRITATING. SKIN: CONTACT MAY CAUSE IRRITATION. INJECTION UNDER
SKIN CAUSES NECROSIS. INHALATION: VAPORS (GENERATED AT HIGH
TEMPERATURES ONLY) OR OIL MIST MAY CAUSE MILD IRRITATION TO NOSE,
TROAT, RESPIRATORY TRACT. INGESTION: MAY CAUSE VOMITING, ASPIRATION
(BREATHING) OF VOMITUS INTO THE LUNGS MUST BE AVOIDED AS EVEN SMALL
QUANTITIES MAY RESULT IN ASPIRATION PN EUMONITIS. CHRONIC:
PROLONGED OR REPEATED SKIN CONTACT MAY RESULT IN DEMATITIS OR OIL
ACNE.
Explanation of Carcinogenicity:NO DATA PROVIDED BY RESPONSIBLE PARTY.
Effects of Overexposure:IRRITATION AS PREVIOUSLY NOTED. LOCAL NECROSIS
IS EVIDENCED BY DELAYED ONSET OF PAIN AND TISSUE DAMAGE A FEW HOURS
FOLLOWING INJECTION. ASPIRATION PNEUMONITIS MAY BE EVIDENCED BY
COUGHING, LABORED BRE ATHING AND CYANOSIS (BLUISH SKIN); IN SEVERE
CASES DEATH MAY OCCUR.
Medical Cond Aggravated by Exposure:PERSONS WITH PRE-EXISTING EYE,
SKIN, AND RESPIRATORY DISORDERS MAY BE AGGRAVATED BY EXPOSURE TO
THIS PRODUCT.

First Aid:EYES: FLUSH WITH WATER. IF IRRITATION OCCURS, GET MEDICAL
ATTENTION. SKIN: REMOVE CONTAMINATED CLOTHING. WASH SKIN WITH SOAP
AND WATER. IF IRRITATION OCCURS, GET MEDICAL ATTENTION. IF INJECTED
UNDER S KIN, GET MEDICAL ATTENTION. DO NOT WAIT FOR SYMPTOMS TO
DEVELOP. INHALATION: MOVE TO FRESH AIR. PROVIDE OXYGEN IF BREATHING
DIFFICULT. GET MEDICAL ATTENTION. INGESTION: DO NOT INDUCE
VOMITING. GET MED ICAL ATTENTION.

Flash Point Method:COC
Flash Point:=177.8C, 352.F
Extinguishing Media:WATER FOG, FOAM, DRY CHEMICAL, CARBON DIOXIDE. DO
NOT USE DIRECT STREAM OF WATER. PRODUCT WILL FLOAT AND CAN BE
REIGNITED.
Fire Fighting Procedures:DO NOT ENTER ANY ENCLOSED OR CONFINED AREA
WITHOUT PROPER PROTECTIVE EQUIPMENT AND NIOSH-APPROVED SCBA. COOL
FIRE EXPOSED CONTAINERS WITH WATER.
Unusual Fire/Explosion Hazard:MATERIAL WILL NOT BURN UNLESS PREHEATED.
CONTAINER MAY RUPTURE IN FIRE.

Spill Release Procedures:WEAR RESPIRATOR & PROTECTIVE CLOTHING AS
APPROPRIATE. SHUT OFF SOURCE OF LEAK IF SAFE TO DO SO. DIKE AND
CONTAIN SPILLS. REMOVE WITH VACUUM TRUCK OR PUMP TO
STORAGE/SALVAGE VESSELS. SOAK UP RESIDUE W ITH INERT MATERIAL SUCH
AS SAND, CLAY, EARTH. SHOVEL INTO CONTAINERS FOR DISPOSAL. PREVENT
RUN-OFF FROM ENTERING WATERWAYS, SEWERS. EPA CLASSES MATERIAL AS
OIL.
Neutralizing Agent:NO DATA PROVIDED BY RESPONSIBLE PARTY.

Handling and Storage Precautions:STORE IN A COOL, DRY, ADEQUATELY
VENTILATED PLACE AWAY FROM STRONG OXIDIZERS, OPEN FLAMES, AND HIGH
TEMPERATURES.
Other Precautions:AVOID CONTACT WITH EYES, SKIN. WASH THOROUGHLY AFTER
HANDLING. LAUNDER CLOTHING BEFORE REUSE. AVOID INHALING MISTS.
EMPTY CONTAINERS OF THIS PRODUCT MAY BE HAZARDOUS DUE TO THE
RETENTION OF RESIDUES. DO NOT TAKE INTERNALLY.

Respiratory Protection:NONE NORMALLY REQUIRED. IF EXCESSIVE MISTING IS
EXPECTED OR IF EXPOSURE EXCEEDS RECOMMENDEDPERMISSIBLE EXPOSURE
LIMITS (PEL), WEAR EITHER AN ATMOSPHERE-SUPPLIED RESPIRATOR OR AN
AIR-PURIFYING RESPIRAT OR FOR ORGANIC VAPORS AND PARTICULATES.
Ventilation:PROVIDE VENTILATION REQUIRED TO CONTROL VAPOR
CONCENTRATIONS. GENERAL ROOM VENTILATION SHOULD NORMALLY BE
SUFFICIENT.
Protective Gloves:WEAR NITRILE GLOVES TO MINIMIZE CONTACT.
Eye Protection:SAFETY GLASSES OR GOGGLES AS NEEDED.
Other Protective Equipment:PROVIDE EYE WASH STATION AND SAFETY SHOWER.
WEAR INDUSTRIAL-TYPE WORK CLOTHING AND APRON AS REQUIRED TO
MINIMIZE CONTACT.
Work Hygienic Practices:WASH AFTER HANDLING AND BEFORE EATING,
DRINKING, OR SMOKING. LAUNDER CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
NOTE TO PHYSICIAN: IF MORE THAN 2.0 ML PER KG HAS BEEN INGESTION AND
VOMITING HAS NOT OCCURED,EMESIS SHOULD BE INDUCED WITH SUPERVISION.
KEEP VICTIM"S HEAD BELOW HIPS. IF SYMPTOMS SUCH AS LOSS OF GAG
REFLEX, CONVULSION, OR UNCONSCIOUSNESS OCCUR, GASTRIC LAVAGE USING
A CUFFED ENDOTRACHEAL TUBE SHOULD BE CONSIDERED.

HCC:V6
Boiling Pt:B.P. Text:NOT AVAILABLE
Melt/Freeze Pt:M.P/F.P Text:NOT AVILABLE
Vapor Pres:NOT AVAILABLE
Spec Gravity:0.84
Viscosity:7CS @ 100F
Evaporation Rate & Reference:NOT AVAILABLE
Solubility in Water:NEGLIGIBLE
Appearance and Odor:RED LIQUID. SLIGHT ODOR.

Stability Indicator/Materials to Avoid:YES
AVOID CONTACT WITH STRONG OXDIZING AGENTS.
Stability Condition to Avoid:AVOID HEAT, FLAMES.
Hazardous Decomposition Products:COMPLEX MIXTURE OF AIRBORNE SOLID,
LIQUID, PARTICULATES, GASES EVOLVED. CARBON MONOXIIDE AND OTHER
COMPOUNDS MAY BE FORMED.
Conditions to Avoid Polymerization:WILL NOT OCCUR.

Waste Disposal Methods:IF THIS PRODUCT BECOMES A WASTE. IT WOULD NOT BE
A HAZARDOUS WASTE BY RCRA (40 CFR 261). PLACE IN AN APPROPRIATE
DISPOSAL FACILITY IN COMPLIANCE WITH LOCAL REGULATIONS.

Toxicological Information:NO DATA PROVIDED BY RESPONSIBLE PARTY.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.

Ecological:UNDER EPA/CWA, THIS PRODUCT IS CLASSIFIED AS AN OIL UNDER
SECTION 311. SPILLS INTO OR LEADING TO SURFACE WATERS THAT CAUSE A
SHEEN MUST BE REPORTED TO THE NATIONAL RESPONSE CENTER.,
800-424-8802.

Transport Information:DEPARTMENT OF TRANSPORTATION CLASSIFICATION: NOT
HAZARDOUS BY D.O.T. REGULATIONS.

SARA Title III Information:NO DATA PROVIDED BY RESPONSIBLE PARTY.
Federal Regulatory Information:THE COMPONENTS OF THIS PRODUCT ARE
LISTED ON THE EPA/TSCA INVENTORY OF CHEMICAL SUBSTANCES.
State Regulatory Information:NO DATA PROVIDED BY RESPONSIBLE PARTY.